Search Results for ‘fuel pump’

So I got a 2009 Zx6r and I’m getting a random misfire. The bike will start up and idle/rev fine. I’ll take it around the block and it’ll start to misfire (bog down, different tone in the exhaust). I’ve drained the gas and put a new fuel strainer on the pump and made sure there was no rust or...

Hello All, It's been a while since I have posted here, but I finally am getting to troubleshooting the fuel sensor issue I have with my bike. My low fuel light has never gone on since I purchased it from the previous owner, which hasn't been too bad since I use the trip (but the light would be...

Yes I know the title doesn't make sense so allow me to explain. I'll be as thorough as I can. The fuel pump only kicks in when I press down on the right side of the fuel tank or tilting the left side towards the right when the tank is mounted. When it's level or I push on the left side, it'll...

SOLVED, see my last post I just reassembly my fuel pump after cleaning it, and now my bike is hard to start, i need to prime the fuel pump 3 times by turning the ignition on-off. and the motor will run happily and no problem once it started, rev nicely across rpms till limiter. i think my fuel...

Hello everyone, I recently purchased 2009 zx6r w/3k miles and i am thrilled to join this forum. My bike is stock except for straight piped exhaust, servo cables disconnected. No lights on the dash. When I test drove the motorcycle before buying it, i was able to cycle through all the gears and...

Hello My fuel pump shut down after I ride my bike for 20-50 km at once. Here is my last situation: Yesterday I went out with my bike do to some stuff. After 20km approximately my bike stop working. I tried to start it again but the fuel pump would not start. After 15-20 minutes I tried again and...

Hey all, I recently ripped apart the bike to do routine maintenance and discovered that the previous owner had wired the fuel pump in a weird way. The black and yellow wire is missing from the back of the male connector on the bike. In the wiring diagram, this looks like a ground wire. While...

hey guys, I left my bike out in the rain now my bike wont start. I'm trying to replace my fuel pump and I wasn't able to because the sensor clip is oddly unremovable. I don't want to fidget with it because I feel like the more I tamper with it, the more problems I have to face later. anyways, I...

Due to an unfortunate series of events I recently inherited the very bike I was in the process of learning to ride on. A 1997 ZX6R Took me a while to get started at his house but I managed and got it to mine. I have since been unable to start it unless I spray engine starter and it will fire...

Alright guys so here is the situation . So I have a Kawasaki ninja 636 2005 with 43k miles . Starting having this wierd problem where when I hit power band it would skip or big out for a second almost like it wasn't getting gas . So I took the tank off and looked at the inside and fuel pump and...

So a few weeks ago I was riding on the highway and my bike randomly decides to die, I managed to get off of the road safely but the bike refused to crank again, it was turning over but not catching. a few months ago I was charging the battery and accidentally short circuited the positive lead...

I've done quite a bit of research on this and haven't come up with much. TLDR: Bike starts but cuts out as soon as I apply throttle. If the gas tank is full to the top, the bike works fine. Brand new fuel pump (that is clicking very loudly). Should I buy a fuel pump relay or just investigate...

https://www.youtube.com/watch?v=Szj4QmGyP80 Day 1 bike hesitates at high RPM/WOT Day 2 I clean the sump well, filter "sock" add Fuel system cleaner to tank Day 3 bike runs VERY STRONG for a 35 minute ride then after being shut off for 2 minutes (stopped to polish bike and lube chain) never...

Ok so I started having trouble starting my bike but once I got her up and going everything was normal. Periodical starting issue got worse and I realized the fuel pump wasn't getting its "prime time." Started as the manual suggested, no power to pump go to fuel pump relay. Relay was gravy but...

Hey all, My name is Michael and I just joined the forum and recentley bought a 99' zx6r. I have rode it a couple times but have it stored away because of winter. Any how the battery is dead right now due to it's cold natured, so tonight I jump it off to let it run a little to keep the carb clean...

Any advice would be appreciated, I'm having issues with my 05 636 cutting off! The story: 2 years ago I went down at low speed, but only messed up plastics and scratched up my stator cover. Last season my bike was cutting off a lot while at low rpm (stopped at a light), so I increased the idle...

Any advice would be appreciated, I'm having issues with my 05 636 cutting off! The story: 2 years ago I went down at low speed, but only messed up plastics and scratched up my stator cover. Last season my bike was cutting off a lot while at low rpm (stopped at a light), so I increased the idle...

the bike will start up without the choke (unusual) and run just fine until it hits about 112 degrees then seems like it runs extremely rich. then I noticed through the oil view window that the crank case filled up with gas. ive been through the carbs and bench tested them many times (floats do...

Just bought an 08zx6r with 2100 miles. The bike was only warmed up and ridden in a neighborhood since 2010. When i bought it, bike wouldnt start because of faulty fuel pump so i bought a used one on e-bay. Installed it yesterday and the bike started. Took the bike for a ride today and it runs...

Can anyone help me out with what the specs should be for the fuel pump on a 2001 ZX6R? I have heard some numbers about the pressure cutoff, but haven't seen anything about the flow rate or anything. Does anybody have some detailed specs about the stock fuel pumps? Thanks